Alfa Romeo Veloce Engine 1290cc 750 Series
- 5500.00 £
- Published date: July 9, 2025
-
- Dartmoor National Park, Devon, United Kingdom
Alfa Romeo Veloce Engine 1290cc 750 Series
⭕ Completely rebuilt:
Alfa Romeo Engine Specifications:
1954-1958 750 Series Veloce Un-Numbered Block
1290CC (1300cc Nominal) Engine
Engine Block
-Align Honed - not bored and Align Polished
-Oil Passages drilled and tapped for full oiling of cylinders #2 and #4
-Oil passages scrupulously deburred and cleaned multiple times
-Block pressure washed and then steam cleaned 3 times in succession, high pressure solvent and steam injection in all oil passageways.
-Oil passages sealed with Allen set screws and Green Loctite
Crankshaft
-Crankshaft polished and cut undersize - 0.0010 (ten thousandths) under rod & main bearings installed (OEM NOS Federal Mogul bearings)
-All crankshaft oil passages drilled, cleaned and tapped and threaded, Allen plugs installed with Green Locktite, crank rebalanced
-Rod Journals #2 and #3 drilled and tapped from both sides for full oiling of #2 and #3 rods
-Crankshaft, slinger, spacer, timing gear, front pulley, flywheel and pressure plate static and harmoniously balanced
-NOS OEM main bearing cap washers, nuts and locknuts installed
Rods
-New upper rod bushings installed & reamed to proper wrist pin
tolerances
-Rods shot peened
-Rods balanced
-Rods sized big and little ends
-New OEM Veloce high strength rod bolts installed
Pistons & Liners
-NOS pistons balanced and installed with wrist pins and rings,nominal displacement 1290 ccs.
-NOS OEM piston liners honed for pistons
-Total Seal NOS piston rings installed
-Final Sun Honing Stone cross-cut on piston liner bores
Flywheel
-Flywheel pressure washed and cleaned, shot peened and re-surfaced with Sun Honing Stone
-NOS OEM Sachs pressure plate and clutch driven disc
-Flywheel, pressure plate and clutch driven disc static balanced
-NOS OEM 17mm flywheel retaining bolts and half moon flywheel
lock plates installed with Red Locktite and NOS locking plates
-NOS OEM 750 Veloce Ring Gear installed and balanced
Oil Pump
-Full rebuild with NOS OEM oil pump relief piston, spring and end cap installed
-oil pump pressure relief valve plunger bore cleaned and chamfered
-high capacity oil pressure plunger relief spring installed
-oil pump housing milled to correct tolerance
-high capacity gears installed, shimmed
-gear play checked and set
Water Pump
-Full rebuild with NOS OEM impellor, shaft, bearings and installed
-Upgraded stainless steel impellor seal installed
Cylinder Head
-stock head height head surfaced minimum 10 thousandths material removed
-first stage intake and exhaust ports ported, polished and matched
-head surface polished after re-surfacing & porting operations
-cylinder head pressure washed and steam cleaned three time in succession after surfacing, porting and polishing operations
-NOS valves, guides, springs, seats and seals installed
-Isky racing valve springs installed, heights set
-Camshaft clearances set at 0.0018 (18 thousandths intake) 0.0020 (20 thousandths) exhaust
-Stock intake manifold ported, polished and enlarged, then matched to cylinder head intake ports
-Special high strength German made Reinz reinforced head gasket installed
Misc. Engine Equipment
-NOS OEM Timing Chains - upper and lower
-NOS OEM Timing Sprocket spring, set plate and bolt
-Original timing sprocket assembly dis-assembled and properly rebuilt for low running stress relief of reciprocating gear
-NOS OEM complete gasket set
-Rebuilt Bosch JF-4 ignition distributor
Alfa Romeo Engine Specifications:
1954-1958 750 Series Veloce Un-Numbered Block
1290CC (1300cc Nominal) Engine
Engine Block
-Align Honed - not bored and Align Polished
-Oil Passages drilled and tapped for full oiling of cylinders #2 and #4
-Oil passages scrupulously deburred and cleaned multiple times
-Block pressure washed and then steam cleaned 3 times in succession, high pressure solvent and steam injection in all oil passageways.
-Oil passages sealed with Allen set screws and Green Loctite
Crankshaft
-Crankshaft polished and cut undersize - 0.0010 (ten thousandths) under rod & main bearings installed (OEM NOS Federal Mogul bearings)
-All crankshaft oil passages drilled, cleaned and tapped and threaded, Allen plugs installed with Green Locktite, crank rebalanced
-Rod Journals #2 and #3 drilled and tapped from both sides for full oiling of #2 and #3 rods
-Crankshaft, slinger, spacer, timing gear, front pulley, flywheel and pressure plate static and harmoniously balanced
-NOS OEM main bearing cap washers, nuts and locknuts installed
Rods
-New upper rod bushings installed & reamed to proper wrist pin
tolerances
-Rods shot peened
-Rods balanced
-Rods sized big and little ends
-New OEM Veloce high strength rod bolts installed
Pistons & Liners
-NOS pistons balanced and installed with wrist pins and rings,nominal displacement 1290 ccs.
-NOS OEM piston liners honed for pistons
-Total Seal NOS piston rings installed
-Final Sun Honing Stone cross-cut on piston liner bores
Flywheel
-Flywheel pressure washed and cleaned, shot peened and re-surfaced with Sun Honing Stone
-NOS OEM Sachs pressure plate and clutch driven disc
-Flywheel, pressure plate and clutch driven disc static balanced
-NOS OEM 17mm flywheel retaining bolts and half moon flywheel
lock plates installed with Red Locktite and NOS locking plates
-NOS OEM 750 Veloce Ring Gear installed and balanced
Oil Pump
-Full rebuild with NOS OEM oil pump relief piston, spring and end cap installed
-oil pump pressure relief valve plunger bore cleaned and chamfered
-high capacity oil pressure plunger relief spring installed
-oil pump housing milled to correct tolerance
-high capacity gears installed, shimmed
-gear play checked and set
Water Pump
-Full rebuild with NOS OEM impellor, shaft, bearings and installed
-Upgraded stainless steel impellor seal installed
Cylinder Head
-stock head height head surfaced minimum 10 thousandths material removed
-first stage intake and exhaust ports ported, polished and matched
-head surface polished after re-surfacing & porting operations
-cylinder head pressure washed and steam cleaned three time in succession after surfacing, porting and polishing operations
-NOS valves, guides, springs, seats and seals installed
-Isky racing valve springs installed, heights set
-Camshaft clearances set at 0.0018 (18 thousandths intake) 0.0020 (20 thousandths) exhaust
-Stock intake manifold ported, polished and enlarged, then matched to cylinder head intake ports
-Special high strength German made Reinz reinforced head gasket installed
Misc. Engine Equipment
-NOS OEM Timing Chains - upper and lower
-NOS OEM Timing Sprocket spring, set plate and bolt
-Original timing sprocket assembly dis-assembled and properly rebuilt for low running stress relief of reciprocating gear
-NOS OEM complete gasket set
-Rebuilt Bosch JF-4 ignition distributor
Phone number ✆ 01752 658942
Dartmoor National Park, Devon
Related listings
-
98 01-04 LS1 LS6 Engine T-56 Transmissio...
AUTO PARTS Chesham (Buckinghamshire) July 27, 2025 1000.00 £ -
-
Corvette LS6 Crate Engine W/ 6-Speed T56...
AUTO PARTS Keighley (West Yorkshire) July 27, 2025 1700.00 £
-
-
JDM Subaru EJ20T Engine Impreza STI 04-0...
AUTO PARTS Silverstone (Northamptonshire) July 27, 2025 1800.00 £ -
-
1917 Excelsior Motorcycle Antique Indian...
AUTO PARTS Winchester (Hampshire) July 26, 2025 2700.00 £ -
QUALITY HEALTH KEEP LOCAL DELIVERY MARIJ...
AUTO PARTS Easington Colliery (Durham) July 26, 2025 11.00 £ -
Porsche 997 Turbo Brakes PCCB Carbon Cer...
AUTO PARTS Southwick (West Sussex) July 26, 2025 2600.00 £
-
-
-
ESCORT QUAIFE 5 SPEED SEQUENTIAL GEARBOX...
AUTO PARTS Buckland Newton (Dorset) July 26, 2025 2400.00 £
-
Chevrolet454 ,502,marine,camaro Nova,che...
AUTO PARTS Hartley Wintney (Hampshire) July 26, 2025 1700.00 £ -
-
-
-
Porsche 911 Solex Triple Carburetor Pair...
AUTO PARTS Mapledurham (Oxfordshire) July 26, 2025 1800.00 £ -
BMW B7 ALPINA 7-Series Genuine Wheels Ri...
AUTO PARTS Piercebridge (Durham) July 26, 2025 1500.00 £
-
-
Snap On Tools 20 Drawer Hot Rod KRL Tool...
AUTO PARTS Guiseley (West Yorkshire) July 25, 2025 2600.00 £ -
-
-
MERCEDES BENZ 190SL JUDSON SUPERCHARGER
AUTO PARTS North Yorkshire (North Yorkshire) July 25, 2025 2500.00 £ -
G-FORCE 4 SPEED TRANSMISSION TOP LOAD LO...
AUTO PARTS Copsale (West Sussex) July 25, 2025 1500.00 £
-
BMW E90 E92 E93 M3 Engine Complete With ...
AUTO PARTS Silverstone (Northamptonshire) July 25, 2025 2100.00 £ -
-
-
CLASSIC MINI COOPER 'S' COMPLETE...
AUTO PARTS Clayton le Moors (Lancashire) July 25, 2025 3500.00 £ -
-
Chevrolet Corvette Fuel Injection Engine...
AUTO PARTS Crick (Northamptonshire) July 25, 2025 2000.00 £
-
07 TRAILBLAZER SS 6.0 ENGINE TRANSMISSIO...
AUTO PARTS Westonbirt (Gloucestershire) July 25, 2025 1500.00 £ -
NARDI-DANESE ND 48 - 55 CROSLEY SOLEX DU...
AUTO PARTS Todwick (South Yorkshire) July 25, 2025 1500.00 £ -
-
GPW WWII Ford Jeep Engine MB Military Ar...
AUTO PARTS Billinghurst (West Sussex) July 25, 2025 3000.00 £ -
-
-
Porsche 911 912 Original Recaro Sports S...
AUTO PARTS Haxby (North Yorkshire) July 25, 2025 2400.00 £ -
-
-
BMW Genuine E90 E91 E92 E82 Performance ...
AUTO PARTS Bentley (Worcestershire) July 25, 2025 1700.00 £ -
-
-
-
New Mitsubishi 22hp Diesel Engine L3E-VS...
AUTO PARTS Tormarton (Gloucestershire) July 25, 2025 1600.00 £ -
-
-
-
Mopar Fuel Vapor Emission Canister Dodge...
AUTO PARTS Lostwithiel (Cornwall) July 24, 2025 2800.00 £
-
Bugatti Type 57 Atlante Historic Radiato...
AUTO PARTS Saint Owens Cross (Hertfordshire) July 24, 2025 2300.00 £ -
-
-
-
1967 Chevrolet 427435 High Performance R...
AUTO PARTS Kingsbury (Warwickshire) July 24, 2025 2600.00 £ -
-
Honeywell-Garret Gas Turbine Jet Engine ...
AUTO PARTS Norton (North Yorkshire) July 24, 2025 1400.00 £ -
Porsche Early 911 901 Solex Carb Air Fil...
AUTO PARTS Ticehurst (East Sussex) July 24, 2025 1000.00 £ -
-
-
-
1988 BMW M6 E24 Complete S38 3.5L Engine...
AUTO PARTS Stanford in the Vale (Oxfordshire) July 24, 2025 1400.00 £
-
-
HONDA S2000 ENGINE RACE RALLY DRIFT RALL...
AUTO PARTS Highworth (Wiltshire) July 24, 2025 2400.00 £ -
-
-
-
Harley Davidson Superglide FXE Tank And ...
AUTO PARTS Batley (West Yorkshire) July 24, 2025 1400.00 £
-
-
93-96 Maserati GHIBLI V6 4AC 24V 2.8L EN...
AUTO PARTS Syston (Lincolnshire) July 24, 2025 1900.00 £ -
-
Ford Sierra Sapphire Cosworth Group A MT...
AUTO PARTS Bledington (Oxfordshire) July 24, 2025 3000.00 £ -
-
-
400-600hp CRAWFORD PERFORMANCE TURBO SUB...
AUTO PARTS Ashford in the Water (Derbyshire) July 24, 2025 2200.00 £ -
-
-
-
1963-1965 CORVETTE NOS FUEL INJECTION UN...
AUTO PARTS Canvey Island (Essex) July 24, 2025 2500.00 £ -
Quaife 15G 6 Speed Sequential Gearbox Es...
AUTO PARTS Aylesbury (Buckinghamshire) July 24, 2025 1800.00 £
-
-
-
PORSCHE 911 SOLEX 40 P1PI CARBURETORS Fu...
AUTO PARTS Elstree (Hertfordshire) July 24, 2025 2200.00 £
-
-
Mustang Shelby Gt 500 Cobra 5.4 Engine A...
AUTO PARTS Brierley Hill (West Midlands) July 24, 2025 2200.00 £ -